Premium Only Content
![Testing Ignition Coils on the Mercury 250 Pro XS Optimax Outboard Motor part 1](https://1a-1791.com/video/s8/1/b/U/U/N/bUUNn.qR4e-small-Testing-Ignition-Coils-on-t.jpg)
Testing Ignition Coils on the Mercury 250 Pro XS Optimax Outboard Motor part 1
Testing the ignition coil and spark plug wires on a Mercury 225 Proxs Optimax outboard. These have a 5 pin connector for the ignition coil. This will be the same for any 5 pin ignition coil Optimax outboards by Mercury.
Testing the ignition coils on a Mercury 250 Pro XS Optimax outboard motor is an essential part of diagnosing and troubleshooting ignition system issues. If you suspect a problem with the ignition coils, you can follow these steps to test them:
Note: Before you begin testing, ensure that the ignition is off, and the battery is disconnected to prevent any accidental starts.
Tools and Equipment Needed:
Multimeter (digital or analog)
Socket set or wrenches
Spark plug socket and spark plug gap tool
Step 1: Safety Precautions
Ensure that the outboard motor is in neutral and the emergency stop switch is pulled out to disable the ignition.
Disconnect the battery to prevent electrical shocks or accidental engine starts.
Step 2: Locate the Ignition Coils
On the Mercury 250 Pro XS Optimax, the ignition coils are typically located on top of the cylinder head or cylinder block near the spark plugs. You may need to remove any covers or components to access them.
Step 3: Remove Spark Plugs
Use a spark plug socket and wrench to remove the spark plugs from the cylinders. This will make it easier to test the ignition coils.
Step 4: Test the Primary Circuit
Set your multimeter to the ohms (Ω) setting.
Connect one probe to the positive terminal of the ignition coil and the other probe to the negative terminal. You should read a low resistance value, typically around 0.5 to 3 ohms, depending on the specific coil.
If the resistance is significantly higher or lower than the expected range, it may indicate a problem with the coil's primary winding, and the coil may need replacement.
Step 5: Test the Secondary Circuit
Set your multimeter to the kilo-ohms (kΩ) setting.
Connect one probe to the center terminal of the ignition coil (where the spark plug wire connects) and the other probe to either the positive or negative terminal (whichever you didn't test in the previous step).
You should read a high resistance value, typically in the range of 5,000 to 15,000 ohms, depending on the coil.
If the resistance is significantly higher or lower than the expected range, it may indicate a problem with the coil's secondary winding, and the coil may need replacement.
Step 6: Repeat for Each Coil
If your outboard motor has multiple ignition coils (which it likely does), repeat steps 4 and 5 for each coil.
Step 7: Reinstall Spark Plugs
After testing all the ignition coils, reinstall the spark plugs and tighten them securely.
Step 8: Reconnect the Battery
Reconnect the boat's battery.
Step 9: Test the Engine
Start the engine and check for any improvement in engine performance. If the ignition coils were the source of the problem, the issue should be resolved.
If you find that one or more ignition coils have failed the resistance tests, it is recommended to replace the faulty coil(s) with new ones. Make sure to use genuine Mercury replacement parts for optimal performance and reliability. If the issue persists after replacing the coils, consider consulting a certified marine mechanic or technician for further diagnosis and repair
Please visit Hawkeye Marine@ http://www.hawkeyemarine.net. Products for your boat.
--------------Social Media-------------------
Facebook: https://www.facebook.com/hawkeyemarine
Twitter: https://twitter.com/hawkeyemarine
Ebay Store: https://www.ebay.com/usr/hawkeyemarine
-
24:28
Hawkeye Marine
10 months ago $0.02 earnedChecking some coils on a Johnson outboard
391 -
1:19:23
Josh Pate's College Football Show
11 hours ago $4.58 earnedBig Ten Program Rankings | What Is College Football? | Clemson Rage| Stadiums I Haven’t Experienced
66K1 -
LIVE
Vigilant News Network
16 hours agoBombshell Study Reveals Where the COVID Vaccine Deaths Are Hiding | Media Blackout
2,204 watching -
1:17:59
Sarah Westall
12 hours agoDOGE: Crime & Hysteria bringing the Critics & the Fearful - Plus new CDC/Ukraine Crime w/ Dr Fleming
74.6K7 -
45:39
Survive History
18 hours ago $10.41 earnedCould You Survive in the Shield Wall at the Battle of Hastings?
75.3K6 -
1:50:28
TheDozenPodcast
16 hours agoViolence, Abuse, Jail, Reform: Michael Maisey
110K4 -
23:01
Mrgunsngear
1 day ago $6.55 earnedWolfpack Armory AW15 MK5 AR-15 Review 🇺🇸
93.8K12 -
25:59
TampaAerialMedia
1 day ago $4.34 earnedUpdate ANNA MARIA ISLAND 2025
60K4 -
59:31
Squaring The Circle, A Randall Carlson Podcast
19 hours ago#039: How Politics & War, Art & Science Shape Our World; A Cultural Commentary From Randall Carlson
45.8K3 -
13:21
Misha Petrov
18 hours agoThe CRINGIEST Thing I Have Ever Seen…
37.5K70